|
|
1. Identification of the substance/preparation and of the company/undertaking |
Identification of the product | ||
Catalogue No.: | 803184 | |
Product name: | Vinyl acetate (stabilised with 15 ppm hydroquinone) for synthesis |
Manufacturer/supplier identification | ||
Company: |
Merck Ltd. 9th Floor, Monterey Tower, 2170 New Petchburi Road, Bangkapi, Huaykwang, Bangkok 10320 Tel: (662) 308 - 0218 |
2. Composition/information on ingredients |
Synonyms |
Acetic acid vinyl ester |
CAS-No.: | 108-05-4 | EC-Index-No.: | 607-023-00-0 | ||
Molar mass: | 86.09 | EINECS-No.: | 203-545-4 | ||
Molecular formula: | C4H6O2 |
3. Hazards identification |
Highly flammable. |
4. First aid measures |
After skin contact: wash off with plenty of water. Dab with polyethylene glycol 400. Immediately remove contaminated clothing. After eye contact: rinse out with plenty of water for at least 10 minutes with the eyelid held wide open. Immediately summon eye specialist. After swallowing: administer liquid paraffin, avoid vomiting (risk of aspiration!). After inhalation: fresh air. If necessary, apply mouth-to-mouth resuscitation or mechanical ventilation. Summon doctor. |
5. Fire-fighting measures |
Suitable extinguishing media: |
Water, CO2, foam, powder. |
Special risks: |
Combustible. Keep away from sources of ignition. |
6. Accidental release measures |
Take up with liquid-absorbent material (e.g. Chemizorb® ). Forward for disposal. Clean up affected area. Do not inhale vapours. |
7. Handling and storage |
Handling: |
No further requirements. |
Storage: |
tightly closed , protected from heat , protected from light , in a well-ventilated place , cool , away from sources of ignition , away from combustible substances , limitation of storage Take measures to prevent electrostatic charging. |
8. Exposure controls/personal protection |
Specific control parameter | ||
MAK Germany (max. workplace conc.) | ||
Vinyl acetate | 10 ml/m3 or 36 mg/m3 |
Personal protective equipment: | |
Respiratory protection: | required when vapours/aerosols are generated. |
Eye protection: | required |
Hand protection: | required |
Industrial hygiene: | Change contaminated clothing. Wash hands after working with substance. |
9. Physical and chemical properties |
Form: | liquid | |||
Colour: | colourless | |||
Odour: | sweetish | |||
pH value | (20 °C) | 7 | ||
Viscosity | dynamic | (20 °C) | 0.43 mPa*s | |
Melting temperature | -100 °C | |||
Boiling temperature | 71 - 73 °C | |||
Ignition temperature | 385 °C | |||
Flash point | -8 °C | |||
Explosion limits | lower | 2.6 Vol% | ||
upper | 13.4 Vol% | |||
Vapour pressure | (20 °C) | 113 hPa | ||
Density | (20 °C) | 0.93 g/cm3 | ||
Solubility in | water | (20 °C) | 20 g/l | |
ethanol | (20 °C) | freely soluble | ||
ether | (20 °C) | freely soluble |
Further information |
Distillable in an undecomposed state at normal pressure. |
10. Stability and reactivity |
Conditions to be avoided |
no information available |
Substances to be avoided |
heat , acids , alkalis and peroxi compounds |
Hazardous decomposition products |
no information available |
Further information |
heat-sensitive , light-sensitive , sensitive to moisture |
11. Toxicological information |
Acute toxicity |
LD50 (oral, rat): 2920 mg/kg LD50 (dermal, rabbit): 2335 mg/kg |
Further toxicological information |
After skin contact: Slight irritations. After eye contact: Slight iritations. Effect potentiated by: ethanol The possibility of an embryotoxic effect has not yet been fully assessed. |
Further data |
The product should be handled with the care usual when dealing with chemicals. |
12. Ecological information |
bacteria EC0: < 1000 mg/l Adverse ecological effects cannot be excluded in the event of improper handling or disposal. |
13. Disposal considerations |
Product: |
There are no uniform EC Regulations for the disposal of chemicals or residues. Chemical residues generally count as special waste. The disposal of the latter is regulated in the EC member countries through corresponding laws and regulations. We recommend that you contact either the authorities in charge or approved waste disposal companies which will advise you on how to dispose of special waste. |
Packaging: |
Disposal in compliance with official regulations. Handle contaminated packaging in the same way as the substance itself. If not officially specified differently, non-contaminated packaging may be treated like household waste or recycled. |
14. Transport information |
Transport over land ADR/RID and GGVS/GGVE (Germany) | ||||
GGVS/GGVE class: | 3 | Number and letter: | 3b | |
ADR/RID class: | 3 | Number and letter: | 3b | |
Name of material: | 1301 VINYLACETAT, STABILISIERT |
River transport ADN/ADNR | |||
not examined |
Sea transport IMDG | ||||||
IMDG class: | 3.2 | UN-No.: | 1301 | Packaging group: | II | |
Ems: | 3-07 | MFAG: | 330 | |||
Correct technical name: | VINYL ACETATE, INHIBITED |
Air transport ICAO-TI and IATA-DGR | |||||
ICAO/IATA class: | 3 | UN/ID-No.: | 1301 | Packaging group: | II |
Correct technical name: | VINYL ACETATE, INHIBITED |
The transport regulations are cited according to international regulations and in the form applicable in Germany (GGVS/GGVE). Possible national deviations in other countries are not considered. |
15. Regulatory information |
Labelling according to EC Directives | ||
Symbol: | F | Highly flammable immediately and show this container or label. |
R-phrases: | R 11 | Highly flammable. |
S-phrases: | S 16-23.2-29-33 | Keep away from sources of ignition - No smoking. Do not breathe vapour. Do not empty into drains. Take precautionary measures against static discharges. |
EC-No.: | 203-545-4 | EC label |
German regulations | ||
Water pollution class | 2 | (polluting substance) |
16. Other information |
Change in the chapter on ecology. |